User manual ZANUSSI WDT1275-B

[. . . ] Never use steam or steam machines to clean the appliance. · · Child Safety · This appliance has been designed to be operated by adults and children under supervision. Young children MUST NOT be allowed to tamper with the controls or play near or with the oven. This appliance is not intended for use by children or other persons whose physical, sensory or mental capabilities or lack of experience and knowledge prevents them from using the appliance safely without supervision or instruction by a responsible person to ensure that they can use the appliance safely. Accessible parts of this appliance may become hot when it is in use. [. . . ] Viale Bologna, 298 47100 FORLÌ (Italy) 3 Instruction for the User Once the hob has been installed, it is important to remove any protective materials, which were put on in the factory. Hob burners control knobs The hob burners control knobs are situated on the hob right hand side. The symbols on the knobs mean that: there is no gas supply there is maximum gas supply there is minimum gas supply Lighting the burners For easier lighting, proceed before putting a pan on the pan support. push in the relevant knob and turn it anticlockwise to "maximum position". Then, check the flame is regular and adjust it as required. If you cannot light the flame even after several attempts, check the "cap" (Fig. To put the flame out, turn the knob to the symbol . · Always turn the flame down or put it out before taking the pans off the burner. In the absence of electricity, ignition can occur without the electrical device; in this case approach the burner with a flame, push the relevant knob down and turn it anti-clockwise until it reaches the "maximum" position. Do not keep the control knob pressed for more than 15 seconds. If the burner does not light even after 15 seconds, release the control knob, turn it the "off" position and wait for at least one minute before trying to light the burner again. Fig. 1 A - Burner cap B - Burner crown C - Burner body Burner minimum diameter 180 mm 120 mm 80 mm maximum diameter 260 mm 220 mm 160 mm Large (rapid) Medium (semirapid) Small (auxiliary) Using the hob correctly To ensure maximum burner efficiency, it is strongly recommended that you use only pots and pans with a bottom fitting the size of the burner used, so that flame will not spread beyond the bottom of the vessel (see the table beside) (Fig. The flexible pipe must be tightly fixed using clamps according to the rules in force. LPG : use the rubber pipe holder «D» (Fig. Always insert the gasket «B». The flexible pipe should be made ready for use in such a way that: - nowhere it can reach overtemperature, other than room temperature, higher than 30°C; if the flexible pipe, to reach the cock, must run behind the range, it must be installed as shown in Fig. 4; - it is no longer than 1500 mm; - it shows no throttles; - it is not subject to traction or torsion; - it doesn't get in touch with cutting edges or corners; - it can be easily inspected in order to check its condition. The control of preservation of the flexible pipe consists in checking that: - it doesn't show cracks, cuts, marks of burnings both on the end parts and on its full extent; - the material is not hardened, but shows its normal elasticity; - the fastening clamps are not rusted; - expiry term is not due. If one or more abnormalities are seen, do not repair the pipe, but replace it. Fig. 4 A) B) C) D) Ramp with ending nut Seal Adjustable connection Rubber pipe holder for LPG Important Once installation is complete, check the perfect seal of every pipe fitting, using a soapy solution, never a flame 7 Adaptation to different types of gas Injectors replacement · Remove the pan supports. · Remove the burner's caps and crowns. · With a socket spanner 7 unscrew and remove the injectors (Fig. 5), and replace them with the ones required for the type of gas in use (see table 2). [. . . ] 6 By-pass screws Table 1 : By-pass diameters Burner Ø By-pass in 1/100 of mm. 42 32 28 Rapid Semi-rapid Auxiliary Table 2 : injectors TYPE OF GAS TYPE OF BURNER INJECTORS MARKS 1/100 mm NOMINAL POWER INPUT KW REDUCED POWER kW NOMINAL POWER 3 m /h g/h NOMINAL PRESSURE mbar NATURAL Rapid (large) GAS Semi-rapid (medium) G 20 Auxiliary (small) LPG (Buthane/ Propane) 113 96 70 2, 80 2, 00 1, 00 0, 75 0, 45 0, 33 0, 267 0, 190 0, 095 - 20 Rapid (large) Semi-rapid (medium) Auxiliary (small) 86 71 50 108 105 80 2, 80 2, 00 1, 00 2, 13 1, 72 0, 90 0, 75 0, 45 0, 33 0, 52 0, 42 0, 30 0, 210 0, 186 0, 085 204 145 73 - 30 NATURAL Rapid (large) GAS Semi-rapid (medium) G 20 Auxiliary (small) 13* 8 * for Russia only. Building In SR R SR A 58 0 0 50 This hob can be inserted in a built-in kitchen unit whose depth is between 550 and 600 mm. The hob dimensions are shown in the relevant diagram. The edge of the cut out must have a minimum distance from the rear wall of 55 mm. [. . . ]